Separation selectivity of various gases in the ionic liquid 1-ethyl-3-methylimidazolium tris (pentafluoroethyl) trifluorophosphate

M.A.M. Althuluth, C.J. Peters, A.S. Berrouk, M.C. Kroon

    Research output: Chapter in Book/Report/Conference proceedingConference contributionAcademicpeer-review

    1 Citation (Scopus)

    Abstract

    The separation of carbon dioxide (CO2) from methane (CH4) is an important process in many industrial areas such as natural gas processing and biogas purification [1]. Natural gas also contains significant amounts of ethane, some propane, butane, and other higher hydrocarbons [2]. In natural gas treating, loss of heavy hydrocarbons is a concern. It is desirable to recover these compounds due to practical problems. There are many methods available for the removal of acid gases from gas streams. The most commonly used are chemical solvents, physical solvents, membranes and cryogenic fractionation [3]. Physical solvents tend to be favoured over chemical solvents when the concentration of acid gases is very high. However, if the concentration of heavy hydrocarbons is high, a physical solvent may not be the best option due to higher co-absorption of hydrocarbons. An acceptable solvent should have a high capacity for acid gas and a low capacity for hydrocarbons [4]. Therefore, ILs have been proposed to be used as a solvent for CO2 capture, because of their advantageous properties over conventional ones [5]. We found that the ionic liquid (IL) 1-ethyl-3 methylimidazoliumtris(pentafluoroethyl) trifluorophosphate ([emim][FAP]) shows the highest carbon dioxide (CO2) solubility of all ILs studied so far and shows higher selectivities for CO2/CH4 separations than any other IL, indicating the promising potential of using this IL for the separation of CO2 from natural gas. Also, the solubilities of C2H6, C3H8 and C4H10 in ([emim][FAP]) were measured and compared to the CO2 solubility in the same IL. The separation ratio between CO2 and hydrocarbons decreases as the hydrocarbon chain becomes longer. The selectivity increase accordingly to the order: SCO2/C4H10 <SCO2/C3H8 <SCO2/C2H6 <SCO2/CH4. A maximum selectivity is achieved at lower temperatures. Therefore, the CO2 removal from a natural gas stream is recommended to be performed at low temperatures in order to achieve the best separation. The obtained solubility data are modelled with the Peng-Robinson equation of state combined with quadratic mixing rule. The calculated data have been found to be in a good agreement with the experimental results.
    Original languageEnglish
    Title of host publicationProceedings of the 2013 AICHE Annual Meeting
    Subtitle of host publicationGlobal Challenges for Engineering a Sustainable Future
    PublisherAmerican Institute of Chemical Engineers (AIChE)
    Pages612-613
    Number of pages2
    ISBN (Electronic)9781634390569
    Publication statusPublished - 1 Jan 2013
    Event2013 AIChE Annual Meeting - San Francisco, United States
    Duration: 3 Nov 20138 Nov 2013

    Conference

    Conference2013 AIChE Annual Meeting
    Country/TerritoryUnited States
    CitySan Francisco
    Period3/11/138/11/13

    Fingerprint

    Dive into the research topics of 'Separation selectivity of various gases in the ionic liquid 1-ethyl-3-methylimidazolium tris (pentafluoroethyl) trifluorophosphate'. Together they form a unique fingerprint.

    Cite this